Kia Stinger: Airbag Module / Curtain Airbag (CAB) Module

Kia Stinger CK 2018-2024 Service Manual / Restraint / Airbag Module / Curtain Airbag (CAB) Module

Description and operation

Description

Installed inside the headliner, the curtain airbags (CAB) protect the driver and passengers from danger in the eThe SRSCM determines deployment of curtain airbag based on side impact sensor (SIS) signal.The SRSCM determines deployment of curtain airbag by using side impact sensor (SIS) signal.

Never attempt to measure the circuit resistance of the airbag module even if you are using the specified tester. If the circuit resistance is measured with a tester, accidental airbag deployment will result in serious personal injury.

Components and components location

Components

1. Curtain Airbag (CAB)

Repair procedures

Removal

1.	Disconnect the battery negative terminal, and wait for at least three minutes before beginning to work.

2.	Remove the roof trim. (Refer to Body (Interior and Exterior) - "Roof Trim Assembly")

3.	Disconnect the connector (A) from the curtain airbag module.

Loosen the curtain airbag bolts and nuts and then remove the curtain airbag.

Tightening torque

Bolt : 7.7 - 11.7 N·m (0.79 - 1.2 kgf·m, 5.7 - 8.6 lb·ft)

Nut : 3.8 - 5.8 N·m (0.39 - 0.6 kgf·m, 2.8 - 4.3 lb·ft)

Never twist the airbag module when installing it. If the module is twisted, airbag module may operate abnormally.

Installation

1.	Disconnect the battery negative terminal, and wait for at least three minutes before beginning to work.

2.	Install in the reverse order of removal.

3.	Reconnect the negative battery terminal.

4.	After installing the curtain airbag (CAB), confirm proper system operation: Switch "ON" the ignition. The SRS indicator light should turn on for about six seconds and then off.

Side Airbag (SAB) Module

Description and operation Description Installed inside the front seat, the side airbags (SAB) protect the driver and front passenger from danger in the event of a side crash. The SRSCM ...

Knee Airbag (KAB) Module

Description and operation Description Installed inside the crash pad, the knee airbag (KAB) protects the driver in the event of a frontal crash. The SRSCM determines if and when to de ...

Other information:

Kia Stinger CK 2018-2024 Service Manual: Rear Glass Defogger Printed Heater

Repair procedures Inspection • Wrap tin foil around the end of the voltmeter test lead to prevent damaging the heater line. Apply pressure on the tin foil with hand and move the t ...

Kia Stinger CK 2018-2024 Service Manual: Vacuum Pump

Components and components location Components 3.3 T-GDI LAMBDA II 1. Vacuum pump 2. Vacuum pump bracket 2.0 T-GDI THETA II 1. Vacuum pump 2. Vacuum pump bracket Repair procedures Remov ...